电子封装、QFP和MCM热变形的实验及数值分析

0Introduction Anelectronicpackageisgenerallyconstructedwithanactivesiliconchip,mountisland,gold wires,leadframesandsoldersasshowninFig.1(a).Toprotectfromtheenvironment,thesilicon chipisusuallyencapsulatedinresin.SincethesematerialshavedifferentCTE(coeffic…     

国产润滑油的压粘系数和固化压力

润滑油的压粘系数和固化压力是弹流理论应用于摩擦学工程设计的关键试验数据。本文报道了20种国产润滑油的压粘系数和其中16种润滑油的最小固化压力的测定结果,并对不同油田的基础润滑油、不同化学结构的合成润滑油和不同用途的工业润滑油的压粘系数和固化压力进行了分析比较。     

与冲蚀有关的粘着与犁沟摩擦系数

提出一种与冲击磨损有关的有效摩擦系数，它被定义为冲击过程中，每一瞬间的切向有效摩擦力与法向载荷之比．有效摩擦力被表示为剪切项与犁沟项之组合．剪切项依赖于剪切金屑接合点的状态——滑移或滚动．犁沟项依赖于冲击物在冲击途中使靶材料发生移动的状态．此有效摩擦系数被应用于研究刚性球自由斜冲击延性靶问题．在忽略剪切项仅计及犁沟项的情况下，研究表明，Hutchings实验中的有效冲击摩擦系数是冲击过程与初始冲击角的函数，就时间平均而言，大于Hutchins为拟合计算与实验结果所取的摩擦系数常值0.05．有迹象表明，对于与固粒延性冲蚀有关的刚性球自由斜冲击延性靶问题，在一定条件下，有效摩擦系数主要由犁沟效应确定．     

Effect of incomplete thermal accommodation on intensive subsonic gas condensation

The direct Monte Carlo simulation method is used for investigating the effect of the thermal accommodation coefficient α _E on the relation for the Knudsen layer in the presence of intensive subsonic condensation. It is shown that the deviation of α _E from unity may significantly affect the flow parameters, in particular, M_lim, the Mach number value limiting for subsonic condensation. It is shown that a decrease in α _E leads to an increase in M_lim (M_lim < 1) if the relative flow temperature (ratio of the outer Knudsen layer boundary to the surface temperature) T < 1 and to a decrease in M_lim if T > 1. It is shown that for mirror reflection of molecules from the surface this effect may intensify.     

侧槽的拘束作用及对断裂韧性参量的影响

本文研究了侧槽对预制疲劳裂纹Ｃｈａｒｐｙ尺寸试样的拘束效应以及其对断裂韧性参量的影响。当侧槽深度大于临界值时，峰值载荷韧性Ｊｍ值与起裂韧性Ｊ１值基本相等。侧槽对试样的加厚作用可用试样的附加厚度表示，对于同样的侧槽深度，不同材料具有不等的附加厚度，试样取得最大附加厚度的侧槽深度为３３％。文中提出用拘束系数定量地估计侧槽对裂纹尖端的塑性拘束作用，能较好地解解放本试验结果。     

An experimental investigation of heat transfer to pulsating pipe air flow with different amplitudes

Heat transfer characteristics to both laminar and turbulent pulsating pipe flows under different conditions of Reynolds number, pulsation frequency, pulsator location and tube diameter were experimentally investigated. The tube wall of uniform heat flux condition was considered for both cases. Reynolds number varied from 750 to 12,320 while the frequency of pulsation ranged from 1 to 10 Hz. With locating the pulsator upstream of the inlet of the test section tube, results showed an increase in heat transfer rate due to pulsation by as much as 30% with flow Reynolds number of 1,643 and pulsation frequency of 1 Hz, depending on the upstream location of the pulsator valve. Closer the valve to the tested section inlet, the better improvement in the heat transfer coefficient is achieved. Upon comparing the heat transfer results of the upstream and the downstream pulsation, at Reynolds number of 1,366 and 1,643, low values of the relative mean Nusselt number were obtained with the upstream pulsation. Comparing the heat transfer results of the two studied test sections tubes for Reynolds number range from 8,000 to 12,000 and pulsation frequency range from 1.0 to 10 Hz showed that more improvement in heat transfer rate was observed with a larger tube diameter. For Reynolds number ranging from 8,000 to 12,000 and pulsation frequency of 10 Hz, an improvement in the relative mean Nusselt number of about 50% was obtained at Reynolds number of 8,000 for the large test section diameter of 50 mm. While, for the small test section diameter of 15 mm, at same conditions of Reynolds number and frequency, a reduction in the relative mean Nusselt number of up to 10% was obtained.     

On damping coefficient due to phase transformation

The damping coefficient of capillary waves due to the evaporation-condensation process at the interface of the two phases of a fluid is evaluated. To highlight the mechanism of the effect of heat and mass transfer across the interface between regions of liquid and vapor, potential flow of incompressible fluids are assumed. Thus other mechanisms of damping are neglected. To fascilitate the analysis, the method of multiple-scale is employed in the analysis, even though the problem is linear.     

线性随机桁架结构的平稳随机响应分析

研究了随机桁架结构的平稳随机响应问题。同时考虑结构的物理参数、几何尺寸的随机性，从结构平稳随机响应在频域上的表达式出发，利用求解随机变量函数矩的方法，导出了随机桁架结构在平稳随机激励下位移响应均方值的均值、均方差和变异系数的计算表达式。通过算例考察了随机荷载激励下结构物理参数、几何尺寸的随机性对结构随机响应的影响。